General Disclaimer: (HV) (DC) injury or death hazard, use at your own risk, may void warranty. |
Difference between revisions of "Maker Faire Photos"
(PhotoShow 3) |
({{PiPrius-Menu|mw-collapsed}}{{TOCright}}) |
||
(13 intermediate revisions by the same user not shown) | |||
Line 1: | Line 1: | ||
− | + | {{PiPrius-Menu|mw-collapsed}}{{TOCright}} | |
− | + | {{Inaugural Maker Faire Post EVent}} | |
− | + | ||
− | |||
− | |||
− | |||
− | |||
<gallery> | <gallery> | ||
Line 12: | Line 8: | ||
Image:100 1153.JPG|[[CAN-View]] (grey) and video signal adapter (black) under passanger seat. | Image:100 1153.JPG|[[CAN-View]] (grey) and video signal adapter (black) under passanger seat. | ||
Image:100 1154.JPG|Removed pieces, storage compartment, spare tire & jack, the carpet can go back. | Image:100 1154.JPG|Removed pieces, storage compartment, spare tire & jack, the carpet can go back. | ||
+ | |||
Image:100 1156.JPG|Seats on the roof, sticker going on the bumper, camera shooting into the trunk. | Image:100 1156.JPG|Seats on the roof, sticker going on the bumper, camera shooting into the trunk. | ||
Image:100 1157.JPG|[[Prius PHEV Schematics|Control Board]] | Image:100 1157.JPG|[[Prius PHEV Schematics|Control Board]] | ||
Image:100 1158.JPG|[[Prius PHEV Schematics|HV/Tap Emulator Board]] | Image:100 1158.JPG|[[Prius PHEV Schematics|HV/Tap Emulator Board]] | ||
Image:100 1159.JPG|Battery Tap/Interconnect strip, with additional length of ribbon cable spliced in. See [[State Of Charge Manipulation]] & [[Battery Tap Emulator]]. | Image:100 1159.JPG|Battery Tap/Interconnect strip, with additional length of ribbon cable spliced in. See [[State Of Charge Manipulation]] & [[Battery Tap Emulator]]. | ||
+ | |||
Image:100 1160.JPG|Delta-Q [[Battery Chargers|battery charger]]. | Image:100 1160.JPG|Delta-Q [[Battery Chargers|battery charger]]. | ||
Image:100 1161.JPG|[[Prius PHEV Battery Options|One of Four sub-pack modules]] made up of 5 12v 20Ah SLA PbA B&B Batteries. | Image:100 1161.JPG|[[Prius PHEV Battery Options|One of Four sub-pack modules]] made up of 5 12v 20Ah SLA PbA B&B Batteries. | ||
+ | Image:100 1162.JPG|The Seats are on the roof | ||
+ | Image:100 1163.JPG|More interior parts on the roof | ||
+ | |||
+ | Image:100 1167.JPG|Makers Faire Crew doing their thing | ||
+ | Image:100 1168.JPG|OEM high power components 1/2 ''(Battery edge, Battery ECU, Tap Connector, Main Contactors, Precharge Resistor)'' | ||
+ | Image:100 1169.JPG|OEM high power components 2/2 ''(Battery edge, Battery ECU, Tap Connector, Main Contactors, Precharge Resistor)'' | ||
+ | Image:100 1170.JPG|HV disconnected to Inverter under hood. | ||
+ | Image:100 1171.JPG|Three connectors on the drivers rear side of the OEM HV box. | ||
+ | Image:100 1172.JPG|Disconnected control ground of one OEM main contactor to control Charge Interlock. | ||
+ | Image:100 1174.JPG|Tapped positive(+12v) control of one OEM main contactor for Ready ''(car on)'' Interlock. | ||
+ | Image:100 1176.JPG|HV rewired [[Image:100_1176-trace.JPG|thumb|100px|Added Traces]] | ||
+ | Image:100 1182.JPG|Rewired Complete, HV (-), (+)Bat, (+)Inv, ribbon tap cable, (+)12v Ready Interlock, (-)Charge Interlock. | ||
+ | Image:100 1183.JPG|''grey'' OEM NiMH pack, and one of about 20 PbA PHEV batteries and half the rack. | ||
+ | Image:100 1187.JPG|''grey'' [[CAN-View]], ''black'' Video converter, HV and interiour nuts and bolts | ||
+ | Image:100 1188.JPG|Misc low power cables under rear passenger door molding. | ||
+ | |||
+ | Image:100 1189.JPG|Misc low power cables over rear passenger wheel well. | ||
+ | Image:100 1201.JPG|Drivers side OEM battery pack brace. | ||
+ | Image:100 1202.JPG|Passenger side OEM battery pack brace. ''forgot the forced air plumbing.'' | ||
+ | Image:100 1204.JPG|Passenger side OEM battery pack forced air exaust. | ||
+ | |||
+ | Image:100 1208.JPG|Passenger side OEM battery pack forced air intake. | ||
+ | Image:100 1211.JPG|Mockup of Electronics Module ''(Shunt, NiMH Contactor, HV Board, Junction Board, Circulation Fan, Fuses, PbA Center Pack Contactor)''. | ||
+ | Image:100 1213.JPG|Mockup of Electronics Module ''(Shunt, NiMH Contactor, HV Board, Junction Board, Circulation Fan, Fuses/'''Control Board''', PbA Center Pack Contactor)''. | ||
+ | Image:100 1212.JPG|Three 50W heating pads. | ||
+ | |||
+ | Image:100 1216.JPG|Full view of Delta-Q [[Battery Chargers|Charger]] install. | ||
+ | Image:100 1217.JPG|Wheel well components GFI, unswitched/switched quad, switched quad, 12v 3A power supply, 110v 500W inverter. | ||
+ | Image:100 1218.JPG|Drop cord spool over accessory battery. | ||
+ | Image:100 1220.JPG|Battery Rack over heating pads. | ||
+ | |||
+ | Image:100 1221.JPG|Ready to wire up the electronics board. | ||
+ | Image:100 1224.JPG|Installation complete, Bypass plugs. | ||
+ | Image:100 1225.JPG|Installation complete, Delta-Q [[Battery Chargers|Charger]]. | ||
+ | Image:100 1227.JPG|Installation complete, Bypass plugs. | ||
+ | |||
+ | Image:100 1231.JPG|HV Board wired. | ||
+ | Image:100 1232.JPG|Control Board wired. | ||
+ | Image:100 1233.JPG|Electronics Module wired. | ||
+ | Image:100 1223.JPG|End of [[Inaugural Maker Faire]] conversion roadtrip. | ||
</gallery> | </gallery> | ||
+ | |||
+ | |||
+ | [[Category:PHEV]] | ||
+ | [[Category:Prius]] | ||
+ | [[Category:CalCars]] | ||
+ | [[Category:PriusBlue]] | ||
+ | [[Category:Maker Faire]] |
Latest revision as of 13:13, 14 June 2020
Click show for a short list of the current PHEV conversion and kit options for the Toyota Prius. |
---|
For Prius conversion details see the Prius PHEV article and comparisons table.
|
--={ PiPrius
}={ Process
}={ fan control
}={ Manzanita Micro
}={ MM-PFC
}={ Mk 3 Reg
}=--
|
---|
--={ More Vehicles: AVI }={ WhiteBird }={ GrayPearl }={ GreenCarCo }=-- |
|
These are photos from the Inaugural Maker Faire of Ryans 2005 Prius named PriusBlue, we also have local Maker Faire Photos.
- Felix Kramer - BETTAH Prize; Bush in Sacramento, CalCars_Maillist:2006./4./15
- Felix Kramer - Maker Faire Day 3: We Have Liftoff!, CalCars_Maillist:2006./4./18
- Jerry Pohorsky - Photoshow 1, Photoshow 2, Photoshow 3
- Amanda Kovattana Make Faire Plug-in Prius Demo
- Video
- 2006.07.05 - TreeHuggerTV - Plug-In Hybrids
- CNet News - video interview with Felix
- The 10 Show - video interview with Felix
- revision3.com - Systm Episode 6 - Maker Faire @ 14:56 - 18:00
CAN-View (grey) and video signal adapter (black) under passanger seat.
Battery Tap/Interconnect strip, with additional length of ribbon cable spliced in. See State Of Charge Manipulation & Battery Tap Emulator.
Delta-Q battery charger.
One of Four sub-pack modules made up of 5 12v 20Ah SLA PbA B&B Batteries.
grey CAN-View, black Video converter, HV and interiour nuts and bolts
Full view of Delta-Q Charger install.
Installation complete, Delta-Q Charger.
End of Inaugural Maker Faire conversion roadtrip.